Home / Service areas /Burlington / AC Repair
AC Repair · Burlington, OntarioAC Repair in Burlington
AC repair in Burlington costs $150–$800 for most faults, after a $90–$150 diagnostic visit that comes off the bill when you approve the work. The usual culprits are a run capacitor, a contactor or a clogged drain line, and those are one-visit fixes at $150–$450. ZK Mechanical dispatches from 4145 North Service Road, so the truck starts its day inside the city.
Burlington air conditioner repair, priced before the work starts
What fails on a Burlington air conditioner depends on when the subdivision was built. Millcroft and the Orchard went up in the 1990s and 2000s, and many of the original condensers there are 15 to 25 years old and charged with R-22, a refrigerant that is no longer produced and is sold only as reclaimed stock. Alton Village units from the 2000s and 2010s run R-410A and have reached the age where the run capacitor and the contactor wear out, which is the cheap end of the repair list. South of the QEW, the 1950s–60s bungalows in Roseland, Shoreacres and Aldershot had central air added decades after the ducts were built for heat alone, so a single return and an overdue filter can starve the coil until it freezes.
The parts are priced the same way on every call. A capacitor or a contactor is $150–$350, a condenser or blower fan motor is $300–$700, a control board is $400–$800, and finding and sealing a refrigerant leak before recharging runs $300–$800 or more. The rule we use at the kitchen table: fix it when the unit is under 12 years old and the repair is less than half the price of a new one. An R-22 system with a leak fails that test, so we put the repair beside a new air conditioner in Burlington at $4,500–$7,000 and let you choose.
Three checks are worth five minutes before you call. Look at the breaker in the panel and the pull-out disconnect on the wall beside the condenser, then at the furnace filter. If the whole street is dark, that is a Burlington Hydro outage and no repair is needed; if the power came back and the condenser only hums, a weak capacitor often gives out on the restart. If the copper line at the furnace is coated in ice, switch cooling off, leave the fan on and let it thaw for a few hours, because a compressor run against a frozen coil can be damaged for good.
Lake Ontario humidity makes the drain a Burlington repair item of its own. An air conditioner pulls litres of water out of muggy air on a July day, the trap grows algae, and in a finished basement the first sign is a wet carpet beside the furnace or a float switch that has shut the cooling off. Downtown lakeshore condos are a different job: the fan coil in the suite belongs to a building system, so check with property management before booking, and see condo HVAC in Burlington. For everything else, the AC repair service page has the full symptom guide, a spring AC tune-up in Burlington catches most of these faults early, and you can book a repair visit online or by phone at (647) 801-1252.
Why ZK Mechanical for ac repair in Burlington
- Dispatched from 4145 North Service Road in Burlington, beside the QEW, not from another city
- Capacitors and contactors carried on the truck, so the most common no-cool calls end in one visit
- ODP-certified refrigerant handling for R-410A and the newer R-32 and R-454B systems
- Straight numbers on R-22 condensers in Millcroft and the Orchard: leak repair priced beside replacement
- Airflow checked in 1950s–60s bungalows south of the QEW, where a single return is often the real cause of a frozen coil
- $90–$150 diagnostic credited toward the repair, with the price in writing before any part is replaced
- Evenings, weekends and holidays billed at the weekday rate on the 24/7 line
Licensed technicians, Burlington dispatch, no overtime charges.
AC Repair in Burlington — FAQs
How much does AC repair cost in Burlington?
Most repairs land between $150 and $800. A capacitor or contactor is $150–$350, a fan motor $300–$700, a control board $400–$800, and a refrigerant leak repair with recharge $300–$800 or more depending on where the leak is. The diagnostic is $90–$150 and is credited when you go ahead. Our AC repair cost answer breaks down each part.
Is it safe to keep running my air conditioner until the technician arrives?
Only if the single symptom is weak cooling, with no ice and no unusual noise. Shut it off at the thermostat if the copper line is iced, if the outdoor unit hums and trips the breaker, if you smell something burnt at the disconnect, or if water is pooling at the furnace. Running through any of those turns a small part into a compressor replacement or a water-damage claim.
My Millcroft air conditioner is original to the house. Is it worth fixing?
If the fault is electrical, usually yes: a capacitor, contactor or fan motor on a 20-year-old condenser is still a sensible repair. If it is leaking R-22, usually no, because reclaimed refrigerant is expensive and the leak will return. We price both in writing on the same visit, and a replacement on existing ducts runs $4,500–$7,000 installed.
Do you repair air conditioners in rural north Burlington?
Yes. Lowville and Kilbride, above the Escarpment, are inside our regular area. Some homes there on propane or electric heat cool with a heat pump or ductless heads instead of a conventional split system, and a heat pump that will not cool is diagnosed the same way as an air conditioner. Tell us what the outdoor unit is when you call so the right parts come along.
Who is allowed to work on the refrigerant side of an AC in Ontario?
Anyone who opens a refrigerant circuit in Ontario needs an Ozone Depletion Prevention (ODP) card, and topping up a leaking system without finding the leak is not a repair. Our technicians carry ODP cards alongside their TSSA gas licences. If the fix needs a new circuit or a replacement disconnect, that part is electrical work and is done to ESA rules.
Other HVAC services in Burlington
AC Repair in Burlington — fast.
Emergency repair or planned upgrade, quoted in writing before any work starts.