Home / Service areas /Etobicoke / Furnace Repair
Furnace Repair · Etobicoke, OntarioFurnace Repair in Etobicoke
Furnace repair in Etobicoke costs $150–$800 for most faults, after a $90–$150 diagnostic that comes off the bill when you approve the work. A TSSA-licensed gas technician drives in from our Burlington shop along the QEW and the Gardiner, often the same day, and you get the price in writing before a panel comes off. If you smell gas or a carbon monoxide alarm is sounding, leave the house first and phone from outside.
What breaks on Etobicoke furnaces, and what the repair costs
Most of the furnaces we repair in Etobicoke sit in post-war bungalows and storey-and-a-half houses, and the house explains the fault more often than the brand does. These homes were built with one return-air grille in the hallway and supply ducts sized for an old low-efficiency furnace. Put a 95% AFUE condensing furnace on that ductwork and it runs hot: the high-limit switch opens, the burners drop out while the blower keeps running, and the heat comes and goes. Swapping the limit switch without fixing the airflow buys a few weeks, so we measure temperature rise and static pressure before any part is ordered.
Venting is the second pattern. A condensing furnace exhausts through plastic pipe out the side wall, and on the narrower lots of Mimico and Long Branch that termination often sits low in a side yard where drifted snow or frost can cap the intake. The furnace tries to light, the pressure switch never proves draft, and the control board locks out; clearing the pipe costs nothing, while a pressure switch that has failed outright is $250–$500. Older furnaces that still vent up a brick chimney beside the water heater get a draft check on every visit, because a blocked or unlined flue is a carbon monoxide problem, not a comfort problem.
Not every Etobicoke home has a furnace. Some older houses in the Kingsway, Mimico and Long Branch heat with a boiler and radiators, a different trade with different parts that we cover under boiler repair in Toronto. The condo towers at Humber Bay Shores use in-suite fan coils fed by the building's plant, and we service the suite side once property management clears access. If you are not sure what you have, look at the floors: no registers means no furnace.
A furnace visit starts with a $90–$150 diagnostic, credited to the repair if you go ahead, and the common parts are a flame sensor at $150–$300, a hot surface igniter at $200–$450, a draft inducer motor at $400–$900, a control board at $500–$1,200 and a blower motor at $500–$1,500. Enbridge Gas supplies the fuel, CSA B149.1 governs the installation, and only a TSSA-licensed technician may work on the gas train, in Etobicoke as everywhere in Ontario. Our furnace repair service page explains the diagnostic step by step, the Etobicoke service area page lists what else we do locally, and emergency HVAC repair in Etobicoke covers a house that is already cold tonight. To book, contact the shop or call (647) 801-1252.
Why ZK Mechanical for furnace repair in Etobicoke
- TSSA-licensed gas technicians on every Etobicoke furnace call, with the licence card shown on request
- Airflow measured on single-return bungalows before a limit switch or control board is blamed
- Side-wall vent and intake terminations checked for snow, frost and clearance in narrow side yards
- Chimney draft tested where an older furnace still shares a brick flue with the water heater
- Diagnostic $90–$150, taken off the invoice when you approve the repair
- No overtime, weekend or holiday surcharge on the 24/7 line
- Lennox, Carrier, Trane, Goodman, Rheem, York, Amana, KeepRite, Daikin and Napoleon furnaces serviced
Licensed technicians, Etobicoke dispatch, no overtime charges.
Furnace Repair in Etobicoke — FAQs
What should I check before booking furnace repair in Etobicoke?
Four things, none needing a tool. Set the thermostat to Heat and a few degrees above room temperature, confirm the furnace switch on the wall or the unit is on, check the breaker, and pull the filter to see whether it is packed grey. Then walk outside and clear snow or frost from the two plastic pipes on the side wall. If Toronto Hydro has had an outage, give the furnace a few minutes to restart before you call.
How much does furnace repair cost in Etobicoke?
Most repairs fall between $150 and $800 after the $90–$150 diagnostic. By part: flame sensor $150–$300, igniter $200–$450, capacitor or pressure switch $250–$500, inducer motor $400–$900, gas valve $500–$1,000, control board $500–$1,200, blower motor $500–$1,500. You get one written figure for your fault before work starts, and it is the same figure at 9 p.m. on a Sunday as on a weekday morning.
Is it safe to keep running a furnace that keeps shutting off?
It depends on what you see and smell. A furnace that short-cycles with no odour is protecting itself; replace the filter, leave it running and book a visit. Shut it off at the switch and call now if you see soot or scorch marks around the burner door, hear the carbon monoxide alarm, or notice a yellow, lifting flame instead of a steady blue one. With a gas smell, leave the house before you phone anyone.
Do you repair heating in Humber Bay Shores condos?
Yes, on the suite side. Those towers heat and cool with fan coil units: a blower, a coil and a control valve behind a panel, fed by hot or chilled water from the building's plant. We replace fan motors, valves and thermostats and clear drain pans once the property manager approves access and confirms the shut-off arrangements. The boilers, chillers and risers belong to the condominium corporation and its own contractor.
My Etobicoke bungalow's furnace is 18 years old. Repair it or replace it?
Use age and the quote together. Under 12 years, repair almost every time. Between 12 and 15, repair when the quote is less than half the price of a new furnace. Past 15, a failed heat exchanger at $1,500–$3,000, a blower motor or a control board usually tips it toward replacement at $4,500–$7,500 installed. Furnace installation in Toronto covers the venting and chimney questions that come with a new unit.
Other HVAC services in Etobicoke
Furnace Repair in Etobicoke — fast.
Emergency repair or planned upgrade, quoted in writing before any work starts.